Design and validation of the neck for a rear impact dummy (biorid i)

wbldb

Linder, Astrid¹; Svensson, Mats Y.¹; Davidsson, Johan¹; Flogård, Anders¹; Lövsund, Per¹; Håland, Yngve²; Jakobsson, Lotta³; Wiklund, Kristina⁴

Design and validation of the neck for a rear impact dummy (biorid i)

Traffic Inj Prev. 2002;3(2):167-174

©2002 Taylor & Francis

Affiliations

¹Crash Safety Division, Department of Machine and Vehicle Systems, Chalmers University of Technology, Göteborg, Sweden

²Autoliv Research AB, Sweden

³Volvo Car Corporation, Sweden

⁴Saab Automobile AB, Sweden
Abstract and keywords

To assess the protective performance of seats and head restraints, occupant models able to mimic the motion of a human in a crash are needed. Hence, a new mechanical dummy neck for low-velocity rear collision tests was developed. The dummy neck consists of seven cervical elements connected by pin joints. The stiffness properties of the neck were represented by rubber blocks mounted between each pair of vertebrae, as well as by muscle substitutes between the head and the first thoracic vertebra (T1). The muscle substitutes consist of cables connected to a unit containing springs and a damper. The neck was validated against volunteer test data (Δv of 7 km/h) and compared with the kinematics of the Hybrid III dummy. The new neck was tested as a part of a new dummy (BioRID) that produced a human-like motion of the T1. The kinematics of the new neck was within the corridor of the volunteers, during the major part of the first 250 ms of the crash event, for both displacement of the head relative to T1 and for the acceleration of the head. This applies to both duration and peak values. When compared with the new neck, the Hybrid III showed an earlier decrease of the horizontal acceleration of the head, less maximum horizontal displacement, and an earlier increase of the rearward angular displacement of the head relative to T1.

Keywords: To assess the protective performance of seats and head restraints, occupant models able to mimic the motion of a human in a crash are needed. Hence, a new mechanical dummy neck for low-velocity rear collision tests was developed. The dummy neck consists of seven cervical elements connected by pin joints. The stiffness properties of the neck were represented by rubber blocks mounted between each pair of vertebrae, as well as by muscle substitutes between the head and the first thoracic vertebra (T1). The muscle substitutes consist of cables connected to a unit containing springs and a damper. The neck was validated against volunteer test data ( j v of 7 km/h) and compared with the kinematics of the Hybrid III dummy. The new neck was tested as a part of a new dummy (BioRID) that produced a human-like motion of the T1. The kinematics of the new neck was within the corridor of the volunteers, during the major part of the first 250 ms of the crash event, for both displacement of the head relative to T1 and for the acceleration of the head. This applies to both duration and peak values. When compared with the new neck, the Hybrid III showed an earlier decrease of the horizontal acceleration of the head, less maximum horizontal displacement, and an earlier increase of the rearward angular displacement of the head relative to T1.
Links

DOI: 10.1080/15389580211995
History

Received: 2001-03-21

Accepted: 2001-07-17

Online: 2010-09-15

Cited Works (31)

Year	Entry
2000	Watanabe Y, Ichikawa H, Kayama O, Ono K, Kaneoka K, Inami S. Influence of seat characteristics on occupant motion in low-speed rear impacts. Accid Anal Prev. March 2000;32(2):243-250.
1978	White AA III, Panjabi MM. Clinical Biomechanics of the Spine. Philadelphia, PA: J.B. Lippincott Company; 1978.
1993	Scott MW, McConnell WE, Guzman HM, Howard RP, Bomar JB, Smith HL, Benedict JV, Raddin JH, Hatsell CP. Comparison of human and ATD head kinematics during low-speed rearend impacts. In: Proceedings of the SAE International Congress & Exposition. March 1-5, 1993; Detroit, MI. Warrendale, PA: Society of Automotive Engineers. SAE 930094.
1995	Parkin S, Mackay GM, Hassan AM, Graham R. Rear end collisions and seat performance: to yield or not to yield. In: 39th Annual Proceedings, Association for the Advancement of Automotive Medicine (AAAM). October 16-18, 1995; Chicago, IL.231-244.
1993	Ono K, Kanno M. Influences of the physical parameters on the risk to neck injuries in low impact speed rear-end collisions. In: Proceedings of the 1993 International IRCOBI Conference on the Biomechanics of Impact. September 8-10, 1993; Eindhoven, The Netherlands.201-212.
1993	van Kampen LTB. Availability and (proper) adjustment of head restraints in the Netherlands. In: Proceedings of the 1993 International IRCOBI Conference on the Biomechanics of Impact. September 8-10, 1993; Eindhoven, The Netherlands.367-377.
1995	Geigl BC, Steffan H, Dippel C, Muser MH, Walz F, Svensson MY. Comparison of head-neck kinematics during rear end impact between standard Hybrid III, RID neck, volunteers and PMTO's. In: Proceedings of the 1995 International IRCOBI Conference on the Biomechanics of Impact. September 13-15, 1995; Brunnen, Switzerland.261-270.
1998	Eichberger A, Steffan H, Geigl B, Svensson M, Boström O, Leinzinger PE, Darok M. Evaluation of the applicability of the neck injury criterion (NIC) in rear end impacts on the basis of human subject tests. In: Proceedings of the 1998 International IRCOBI Conference on the Biomechanics of Impact. September 16-18, 1998; Göteberg, Sweden.321-333.
1998	Linder A, Svensson MY, Davidsson J, Flogård A, Håland Y, Jakobsson L, Lövsund P, Wiklund K. The new neck design for the rear-end impact dummy, BioRID I. In: 42nd Annual Proceedings, Association for the Advancement of Automotive Medicine (AAAM). October 5-7, 1998; Charlottesville, VA.179-192.
1997	Ono K, Kaneoka K. Motion analysis of human cervical vertebrae during low speed rear impacts by the simulated sled. In: Proceedings of the 1997 International IRCOBI Conference on the Biomechanics of Impact. September 24-26, 1997; Hannover, Germany.223-237.
1996	Thunnissen JGM, van Ratingen MR, Beusenberg MC, Janssen EG. A dummy neck for low severity rear impacts. In: Proceedings of the 15th International Technical Conference on the Enhanced Safety of Vehicles (ESV). May 13-16, 1996; Melbourne, Australia.1665-1678.
1996	Boström O, Svensson MY, Aldman B, Hansson HA, Håland Y, Lövsund P, Seeman T, Suneson A, Säljö A, Örtengren T. A new neck injury criterion candidate based on injury findings in the cervical spinal ganglia after experimental neck extension trauma. In: Proceedings of the 1996 International IRCOBI Conference on the Biomechanics of Impact. September 11-13, 1996; Dublin, Ireland.123-136.
1993	Svensson MY, Aldman B, Hansson HA, Lövsund P, Seeman T, Suneson A, Örtengren T. Pressure effects in the spinal canal during whiplash extension motion: a possible cause of injury to the cervical spinal ganglia. In: Proceedings of the 1993 International IRCOBI Conference on the Biomechanics of Impact. September 8-10, 1993; Eindhoven, The Netherlands.189-200.
1983	Robbins DH. Anthropometric Specifications for Mid-Sized Male Dummy, Volume 2. Ann Arbor, MI: University of Michigan Traffic Research Institute (UMTRI); December 1983. UMTRI Publication UMTRI-83-53-2.
1985	Nygren A, Gustafsson H, Tingvall C. Effects of different types of headrests in rear-end collisions. In: Proceedings of the 10th International Technical Conference on Experimental Safety Vehicles (ESV). July 1-4, 1985; Oxford, England.85-90. SAE 856023.
1986	Seemann MR, Muzzy WH III, Lustick LS. Comparison of human and Hybrid III head and neck dynamic response. In: Proceedings of the 30th Stapp Car Crash Conference. October 27-29, 1986; San Diego, CA. Warrendale, PA: Society of Automotive Engineers:291-311. SAE 861892.
2000	Jakobsson L, Lundell B, Norin H, Isaksson-Hellman I. WHIPS: Volvo’s whiplash protection study. Accid Anal Prev. March 2000;32(2):307-319.
1990	The Abbreviated Injury Scale-1990 Revision. Des Plaines, IL: Association for the Advancement of Automotive Medicine (AAAM); 1990.
1996	Morris AP, Thomas P. A study of soft tissue neck injuries in the UK. In: Proceedings of the 15th International Technical Conference on the Enhanced Safety of Vehicles (ESV). May 13-16, 1996; Melbourne, Australia.1412-1425.
1999	Panjabi MM, Wang J-L, Delson N. Neck injury criterion based on intervertebral motions and its evaluation using an instrumented neck dummy. In: Proceedings of the 1999 International IRCOBI Conference on the Biomechanics of Impact. September 23-24, 1999; Sitges, Spain.179-190.
1998	Linder A, Jernström C, Svensson MY, Lövsund P. A mathematical model of an improved neck for a rear-end impact dummy. In: Proceedings of the 1998 International IRCOBI Conference on the Biomechanics of Impact. September 16-18, 1998; Göteberg, Sweden.553-556.
1998	Krafft M. Non-Fatal Injuries to Car Occupants: Injury Assessment and Analysis of Impacts Causing Short- and Long-Term Consequences With Special Reference to Neck Injuries [PhD thesis]. Stockholm, Sweden: Karolinska Institute; 1998.
1992	Svensson MY, Lövsund P. A dummy for rear-end collisions: development and validation of a new dummy-neck. In: Proceedings of the 1992 International IRCOBI Conference on the Biomechanics of Impact. September 9-11, 1992; Verona, Italy.299-310.
1997	Siegmund GP, King DJ, Lawrence JM, Wheeler JB, Brault JR, Smith TA. Head/neck kinematic response of human subjects in low-speed rear-end collisions. In: Proceedings of the 41st Stapp Car Crash Conference. November 13-14, 1997; Lake Buena Vista, FL. Warrendale, PA: Society of Automotive Engineers:357-385. SAE 973341.
1994	von Koch M, Nygren A, Tingvall C. Impairment pattern in passenger car crashes: a follow-up of injuries resulting in long-term consequences. In: Proceedings of the 14th International Technical Conference on the Enhanced Safety of Vehicles (ESV). May 23-26, 1994; Munich, Germany.776-781.
1997	Ono K, Kaneoka K, Wittek A, Kajzer J. Cervical injury mechanism based on the analysis of human cervical vertebral motion and head-neck-torso kinematics during low speed rear impacts. In: Proceedings of the 41st Stapp Car Crash Conference. November 13-14, 1997; Lake Buena Vista, FL. Warrendale, PA: Society of Automotive Engineers:339-356. SAE 973340.
1991	Shea M, Edwards WT, White AA, Hayes WC. Variations of stiffness and strength along the human cervical-spine. J Biomech. 1991;24(2):95-107.
1989	Deng Y-C. Anthropomorphic dummy neck modeling and injury considerations. Accid Anal Prev. February 1989;21(1):85-100.
1998	Davidsson J, Svensson MY, Flogård A, Håland Y, Jakobsson L, Linder A, Lövsund P, Wiklund K. BioRID I: a new biofidelic rear impact dummy. In: Proceedings of the 1998 International IRCOBI Conference on the Biomechanics of Impact. September 16-18, 1998; Göteberg, Sweden.377-390.
2000	Eichberger A, Darok M, Steffan H, Leinzinger PE, Boström O, Svensson MY. Pressure measurements in the spinal canal of post-mortem human subjects during rear-end impact and correlation of results to the neck injury criterion. Accid Anal Prev. March 2000;32(2):251-260.
1972	States JD, Balcerak JC, Williams JS, Morris AT, Babcock W, Polvino R, Riger P, Dawley RE. Injury frequency and head restraint effectiveness in rear-end impact accidents. In: Proceedings of the 16th Stapp Car Crash Conference. November 8-10, 1972; Detroit, MI. Warrendale, PA: Society of Automotive Engineers:228-257. SAE 720967.

Cited By (1)

Year	Entry
2005	Manoogian SJ, Kennedy EA, Duma SM. An Updated Literature Review of Musculoskeletal Injuries to the Human Neck and the Effects of Head-Supported Mass Worn by Soldiers. Fort Rucker, AL: U.S. Army Aeromedical Research Laboratory; October 2005. USAARL Contract Report CR-2006-01.