Biomechanical response of the head, neck and torso to direct impact on the back of male and female volunteers

Ono, Koshiro; Kaneoka, Koji; Fukushima, Makoto; Uwai, Hayata; Ujihashi, Sadayuki

Affiliations

¹Japan Automobile Research Institute – Japan

³Technology Institute of Tokyo - Japan

Abstract and keywords

Low-severity impact at T1, T6, and L1 to the back of volunteers were applied using a newly developed thrust piston with pneumatically charged cylinder (simulated whiplash loading device) in order to simulate the whiplash motions during such impacts. Seven male and two female volunteers were subjected. The average age of the volunteers was 25 years old. The impact of 100-400 N with duration of 50-100 ms was applied to the back of these volunteers. The three impact locations for each volunteer were: 1) the close area of the first thoracic vertebra (T1), 2) the close area of the six thoracic vertebra (T6), and 3) the close area of the first lumbar spine (L1). The test results for human volunteers were compared with the cadaver tests reported in the past.

For T1, T6, and L1 impacts, the lower cervical spine showed an initial flexion during early stages of impact. The neck axial force appeared to be in tension in the early stages within 50 ms for T1 and T6 impacts. On the other hand, the neck axial compression force in the early stages became remarkable for L1 impact. Due to the neck muscle tension, the neck moment was observed to be getting small which eventually resulted to a minimal movement of the head. However, the neck axial compression force was not affected due to the muscle tension. It can be argued that the neck muscle tension did not influence the movement of the spine.

For T1 and T6 impacts, the neck shear force increased while the change in the neck axial compression force was negligible due to the increase in the impact load level. The head rotational angle and the localized motion of cervical spine for female were bigger than that of male using the same impact load level.

It is confirmed that it is necessary to take into account the motion of the spine and/or spine flexibility in evaluating the cause of cervical injuries during low speed rear-end impacts. Furthermore, with this experiment, the difference in the loading condition at the back caused by different impact positions to the spine and the impact load levels could be understood more. This study thus recommends that a new design in the dummy spinal structure must be made in order to obtain an accurate prediction of minor neck injury occurrence.

Keywords: Dummies; Neck; Low-severity impact; Volunteer; Cervical Spine

Cited Works (10)

Year	Entry
1997	Grauer JN, Panjabi MM, Cholewicki J, Nibu K, Dvorak J. Whiplash produces an S-shaped curvature of the neck with hyperextension at lower levels. Spine. November 1997;22(21):2489-2494.
1999	Ono K, Inami S, Kaneoka K, Gotou T, Kisanuki Y, Sakuma S, Miki K. Relationship between localized spine deformation and cervical vertebral motions for low speed rear impacts using human volunteers. In: Proceedings of the 1999 International IRCOBI Conference on the Biomechanics of Impact. September 23-24, 1999; Sitges, Spain.149-164.
1998	Shen W, Wiklund K, Frid S, Swamy B, Nilson G, Humer M. Pressure and load patterns on seat interface: a comparison between human subjects and crash test dummies. In: Proceedings of the 1998 International IRCOBI Conference on the Biomechanics of Impact. September 16-18, 1998; Göteberg, Sweden.453-464.
1995	Walz FH, Muser MH. Biomechanical aspects of cervical spine injuries. In: Proceedings of the SAE International Congress & Exposition. February 27–March 2, 1995; Detroit, MI. Warrendale, PA: Society of Automotive Engineers. SAE 950658.
1997	Ono K, Kaneoka K, Wittek A, Kajzer J. Cervical injury mechanism based on the analysis of human cervical vertebral motion and head-neck-torso kinematics during low speed rear impacts. In: Proceedings of the 41st Stapp Car Crash Conference. November 13-14, 1997; Lake Buena Vista, FL. Warrendale, PA: Society of Automotive Engineers:339-356. SAE 973340.
2002	Ono K, Kaneoka K, Hattori S, Ujihashi S, Takhounts EG, Haffner M, Eppinger RH. Cervical vertebral motions and biomechanical responses to direct loading of human head. In: Proceedings of the 2002 International IRCOBI Conference on the Biomechanics of Impact. September 18-20, 2002; Munich, Germany.
2001	Ono K, Kaneoka K, Sun EA, Takhounts EG, Eppinger RH. Biomechanical response of human cervical spine to direct loading of the head. In: Proceedings of the 2001 International IRCOBI Conference on the Biomechanics of Impact. October 10-12, 2001; Isle of Man, UK.
1993	Svensson MY, Aldman B, Hansson HA, Lövsund P, Seeman T, Suneson A, Örtengren T. Pressure effects in the spinal canal during whiplash extension motion: a possible cause of injury to the cervical spinal ganglia. In: Proceedings of the 1993 International IRCOBI Conference on the Biomechanics of Impact. September 8-10, 1993; Eindhoven, The Netherlands.189-200.
2001	Viano DC, Hardy WN, King AI. Response of the head, neck and torso to pendulum impacts on the back. J Crash Prev Injury Control. 2001;2(4):289-306.
1997	Yoganandan N, Pintar FA. Inertial loading of the human cervical spine. J Biomech Eng. August 1997;119(3):237-240.

Cited By (3)

Year	Entry
2005	Manoogian SJ, Kennedy EA, Duma SM. An Updated Literature Review of Musculoskeletal Injuries to the Human Neck and the Effects of Head-Supported Mass Worn by Soldiers. Fort Rucker, AL: U.S. Army Aeromedical Research Laboratory; October 2005. USAARL Contract Report CR-2006-01.
2004	Ejima S, Ono K, Yamazaki K. Analysis of finite element model for neck injury mechanisms in low-speed rear-end collisions. In: Proceedings of the 2004 International IRCOBI Conference on the Biomechanics of Impact. September 22-24, 2004; Graz, Austria.323-324.
2005	Ejimac S, Ono K, Kaneoka K, Fukushima M. Development and validation of the human neck muscle model under impact loading. In: Proceedings of the 2005 International IRCOBI Conference on the Biomechanics of Impact. September 21-23, 2005; Prague, Czech Republic.245-255.