Evaluation of event data recorders in full systems crash tests

wbldb

Niehoff, Peter¹; Gabler, Hampton C.²; Brophy, John³; Chidester, Chip³; Hinch, John³; Ragland, Carl³

Evaluation of event data recorders in full systems crash tests

Proceedings of the 19th International Technical Conference on the Enhanced Safety of Vehicles (ESV)

Affiliations

¹Rowan University, United States

²Virginia Tech, United States

³National Highway Traffic Safety Administration, United States
Abstract

The Event Data Recorders (EDRs), now being installed as standard equipment by several automakers, are increasingly being used as an independent measurement of crash severity, which avoids many of the difficulties of traditional crash reconstruction methods. Little has been published however about the accuracy of the data recorded by the current generation of EDRs in a real world collision. Previous studies have been limited to a single automaker and full frontal barrier impacts at a single test speed. This paper presents the results of a methodical evaluation of the accuracy of newgeneration (2000-2004) EDRs from General Motors, Ford, and Toyota in laboratory crash tests across a wide spectrum of impact conditions. The study evaluates the performance of EDRs by comparison with the laboratory-grade accelerometers mounted onboard test vehicles subjected to crash loading over a wide range of impact speeds, collision partners, and crash modes including full frontal barrier, frontaloffset, side impact, and angled frontal-offset impacts. The study concludes that, if the EDR recorded the full crash pulse, the EDR average error in frontal crash pulses was just under six percent when compared with crash test accelerometers. In many cases, however, current EDRs do not record the complete crash pulse resulting in a substantial underestimate of delta-V.
Links

URL: http://www-nrd.nhtsa.dot.gov/pdf/esv/esv19/05-0271-W.pdf

Cited Works (5)

Year	Entry
1998	Stucki SL, Fessahaie O. Comparison of measured velocity change in frontal crash tests to NASS computed velocity change. In: Proceedings of the SAE International Congress & Exposition. February 23-26, 1998; Detroit, MI. Warrendale, PA: Society of Automotive Engineers. SAE 980649.
1998	Lenard J, Hurley B, Thomas P. The accuracy of CRASH3 for calculating collision severity in modern European cars. In: Proceedings of the 16th International Technical Conference on the Enhanced Safety of Vehicles (ESV). May 31–June 4, 1998; Windsor, Ontario, Canada.1242-1249.
1996	O'Neill B, Preuss CA, Nolan JM. Relationships between computed delta V and impact speeds for offset crash tests. In: Proceedings of the 15th International Technical Conference on the Enhanced Safety of Vehicles (ESV). May 13-16, 1996; Melbourne, Australia.1433-1440.
2001	Chidester ACB, Hinch J, Roston TA. Real world experience with event data recorders. In: Proceedings of the 17th International Technical Conference on the Enhanced Safety of Vehicles (ESV). June 4-7, 2001; Amsterdam, The Netherlands.
1982	Smith RA, Noga JT. Accuracy and sensitivity of CRASH. In: Proceedings of the 26th Stapp Car Crash Conference. October 20-21, 1982; Ann Arbor, MI. Warrendale, PA: Society of Automotive Engineers:317-334. SAE 821169.

Cited By (28)

Year	Entry
2006	Gabauer DJ, Gabler HC. Comparison of delta-v and occupant impact velocity crash severity metrics using event data recorders. In: 50th Annual Proceedings, Association for the Advancement of Automotive Medicine (AAAM). October 16-18, 2006; Chicago, IL.57-71.
2006	Niehoff P, Gabler HC. The accuracy of winsmash delta-v estimates: the influence of vehicle type, stiffness, and impact mode. In: 50th Annual Proceedings, Association for the Advancement of Automotive Medicine (AAAM). October 16-18, 2006; Chicago, IL.73-89.
2007	German A, Comeau J-L, McClafferty KJ, Shkrum MJ, Tiessen PF. Event data recorders in the analysis of frontal impacts. In: 51st Annual Proceedings, Association for the Advancement of Automotive Medicine (AAAM). October 15-17, 2007; Melbourne, Australia.225-243.
2008	Funk JR, Cormier JM, Gabler HC. Effect of delta-V errors in NASS on frontal crash risk calculations. In: 52nd Annual Proceedings, Association for the Advancement of Automotive Medicine (AAAM). October 6-8, 2008; San Diego, CA.155-164.
2010	Hampton CE, Gabler HC. Evaluation of the accuracy of NASS/CDS delta-V estimates from the enhanced winsmash algorithm. In: 54th Annual Proceedings, Association for the Advancement of Automotive Medicine (AAAM). October 17-20, 2010; Las Vegas, NV.241-251.
2007	Verma MK, Lange RC, McGarry DC. A study of US crash statistics from automated crash notification data. In: Proceedings of the 20th International Technical Conference on the Enhanced Safety of Vehicles (ESV). June 18-21, 2007; Lyon, France.
2007	Sharma D, Stern S, Brophy J, Choi E-H. An overview of NHTSA’s crash reconstruction software WinSMASH. In: Proceedings of the 20th International Technical Conference on the Enhanced Safety of Vehicles (ESV). June 18-21, 2007; Lyon, France.
2009	Ishikawa H, Takubo N, Oga R, Kato K, Okuno T, Nakano K, Ikari T. Study on pre-crash and post-crash information recorded in electronic control units (ECUS) including event data recorders. In: Proceedings of the 21st International Technical Conference on the Enhanced Safety of Vehicles (ESV). June 15-18, 2009; Stuttgart, Germany.
2009	Craig M, Scarboro M, Flannagan C. Combining CIREN and NASS-CDS data to predict occupant outcomes in frontal crashes. In: Proceedings of the 21st International Technical Conference on the Enhanced Safety of Vehicles (ESV). June 15-18, 2009; Stuttgart, Germany.
2011	Craig MJ, Scarboro M, Ridella SA. Predicting occupant outcomes with EDR data. In: Proceedings of the 22nd International Technical Conference on the Enhanced Safety of Vehicles (ESV). June 13-16, 2011; Washington, DC.
2011	German A, Dalmotas D, Comeau J-L. Crash pulse data from event data recorders in rigid barrier tests. In: Proceedings of the 22nd International Technical Conference on the Enhanced Safety of Vehicles (ESV). June 13-16, 2011; Washington, DC.
2013	Ydenius A, Stigson H, Kullgren A, Sunnevång C. Accuracy of Folksam electronic crash recorder (ECR) in frontal and side impact crashes. In: Proceedings of the 23rd International Technical Conference on the Enhanced Safety of Vehicles (ESV). May 27-30, 2013; Seoul, South Korea.
2017	Wusk G, Gabler H. Evaluation of vehicle-based crash severity metrics using event data recorders. In: Proceedings of the 25th International Technical Conference on the Enhanced Safety of Vehicles (ESV). June 5-8, 2017; Detroit, MI.
2017	Gabler HC, Sharma D. Accuracy of WinSMASH in rear crashes using event data recorders. In: Proceedings of the 25th International Technical Conference on the Enhanced Safety of Vehicles (ESV). June 5-8, 2017; Detroit, MI.
2019	Doecke S, Kloeden C, Paine M. Speeding in crashes in the United States of America: a pilot study using event data recorder information from NASS-CDS. In: Proceedings of the 26th International Technical Conference on the Enhanced Safety of Vehicles (ESV). June 10-13, 2019; Eindhoven, Netherlands.
2014	Adolph T, Eggers A, Thomson R, Mizuno K. Comparison of the dummy response in two different restraint system crash tests. In: Proceedings of the 2014 International IRCOBI Conference on the Biomechanics of Injury. September 10-12, 2014; Berlin, Germany.545-561.
2019	Brumbelow ML. Front crash injury risks for restrained drivers in good-rated vehicles by age, impact configuration, and EDR-based delta V. In: Proceedings of the 2019 International IRCOBI Conference on the Biomechanics of Injury. September 11-13, 2019; Florence, Italy.560-574.
2023	Brumbelow ML. Sex-related vehicle and crash differences and their potential to confound relative injury risk analyses. In: Proceedings of the 2023 International IRCOBI Conference on the Biomechanics of Injury. September 13-15, 2023; Cambridge, United Kingdom.254-265.
2024	Ressi F, Klug C. Stochastic replication of injury risks in frontal collisions with different human body models in a generic vehicle interior. In: Proceedings of the 2024 International IRCOBI Conference on the Biomechanics of Injury. September 11-13, 2024; Stockholm, Sweden.1168-.
2008	Gabauer DJ, Gabler HC. Comparison of roadside crash injury metrics using event data recorders. Accid Anal Prev. March 2008;40(2):548-558.
2005	Niehoff P. The Accuracy of Energy-Based Crash Reconstruction Techniques Using Event Data Recorder Measurements [Master's thesis]. Rowan University; May 2005.
2008	Gabauer DJ. Predicting Occupant Injury With Vehicle-Based Injury Criteria in Roadside Crashes [PhD thesis]. Virginia Polytechnic Institute and State University; June 6, 2008.
2009	Swanseen KD. Effect of Belt Usage Reporting Errors on Injury Risk Estimates [Master's thesis]. Virginia Polytechnic Institute and State University; December 9, 2009.
2010	Hampton CE. Injury Risk of Road Departure Crashes Using Modeling and Reconstruction Methods [PhD thesis]. Virginia Polytechnic Institute and State University; August 10, 2010.
2013	Kusano KD. Methodology for Determining Crash and Injury Reduction from Emerging Crash Prevention Systems in the U.S. [PhD thesis]. Virginia Polytechnic Institute and State University; 2013.
2015	Tsoi AH-d. The Potential of Event Data Recorders to Improve Impact Injury Assessment in Real World Crashes [PhD thesis]. Virginia Polytechnic Institute and State University; May 27, 2015.
2019	Tatem WM. The Crash Injury Risk to Rear Seated Passenger Vehicle Occupants [PhD thesis]. Virginia Polytechnic Institute and State University; December 13, 2019.
2023	Dean ME. Applications of Event Data Recorder Derived Crash Severity Metrics to Injury Prevention [PhD thesis]. Virginia Polytechnic Institute and State University; March 20, 2023.